Cat Electronic Technician 2019C v1.

0
Product Status Report

8/26/2024 10:37 AM

Product Status Report

Parameter Value
Engine Serial Number TXW01233
Equipment ID TYE00177
Comments

C18 390F (TXW01233)

Parameter Value
Equipment ID TYE00177
Engine Serial Number TXW01233
ECM Part Number 4176020-00
ECM Serial Number 22546095VJ
Software Group Part Number 4480036-00
Software Group Release Date NOV13
Software Group Description 390F-PLRC-T3-HEX-C18-T4F
Calibration Identification Number Unavailable

Logged Diagnostic Codes [Diagnostic Clock = 8483 hours] - C18 390F (TXW01233)
Code Description Occ. First Last
2247-21 Fuel Transfer Pump Intake Pressure Sensor : Data 1 8483 8483
Drifted Low
3547- 3 Water In Fuel System Switch : Voltage Above 255 7075 8483
Normal
6- 6 Cylinder #6 Injector : Current Above Normal 255 8182 8483
5- 6 Cylinder #5 Injector : Current Above Normal 255 8053 8482
247-14 SAE J1939 Data Link : Special Instruction 36 8115 8455
444- 6 Starter Motor Relay : Current Above Normal 1 8449 8449

Logged Event Codes [Diagnostic Clock = 8483 hours] - C18 390F (TXW01233)
Code Description Occ. First Last
E361 (1) High Engine Coolant Temperature 4 3937 6418
E361 (2) High Engine Coolant Temperature 1 3937 3937

Active Diagnostic Codes - C18 390F (TXW01233)

Code Description
2247-21 Fuel Transfer Pump Intake Pressure Sensor : Data Drifted Low
3547- 3 Water In Fuel System Switch : Voltage Above Normal

Active Event Codes - C18 390F (TXW01233)

Code Description
No Active
Event Codes

System Communication Status - Active Problems - C18 390F (TXW01233)

ECMs Detected Problem Data Link Diagnostic Information
No issues were
reported

System Communication Status - Inactive Problems - C18 390F (TXW01233)

ECMs Detected Problem Data Link Diagnostic Information
No issues were
reported

Current Totals - C18 390F (TXW01233)

Description Value Unit
Total Idle Time 7688:39 hours
Total Fuel 400851 gal
Total Engine #1 Fuel 400851 gal
Total Idle Fuel 17155 gal
Total Max Fuel 693576 gal
Engine Lifetime Hours 27221.1 hours
Average Load Factor 56 %
Engine Starts 12866
Lifetime Total Engine 2504207292 rev
Revolutions
Total Operating Hours 8483.0 hours
Total Engine Idle Shutdown 4
Count
Total Engine Idle Shutdown 3
Overrides Count
Starts/Hour 0.47
Average RPM 1533.25 rpm
Percentage Idle Time 28.24 %
Average Fuel Rate 14.73 gal/h
Overall Load Factor 57 %

Configuration - C18 390F (TXW01233)

Description Value Unit
Equipment ID TYE00177
Engine Serial Number TXW01233
ECM Part Number 4176020-00
ECM Serial Number 22546095VJ
Software Group Part Number 4480036-00
Software Group Release Date NOV13
Software Group Description 390F-PLRC-T3-HEX-C18-T4F
Rating Number 1
Rated Power 544 hp at 1700 rpm
Rated Peak Torque 1812 lb-ft at 1500 rpm
Ether Solenoid Configuration Not Installed
Engine Warm Up Elevated Idle Feature Enabled
Enable Status
Engine Warm Up Elevated Idle Delay Time 10.0 min
Engine Idle Shutdown Enable Status Disabled
Engine Idle Shutdown Delay Time 3.0 min
Engine Fan Purge Cycle Duration 15.0 sec
FLS -68
FTS 94
CAN Communication Protocol Write Seed and Key Access
Security
CAN Communication Protocol Read Seed and Key Access
Security
Total Tattletale 33

Lifetime:Accumulated Time vs Intake Manifold Pressure - C18 390F (TXW01233)

Intake Manifold Pressure( psi ) hours %
<11.603 223.05 3.90
11.603-13.052 144.25 2.53
13.053-14.503 220.90 3.87
14.504-15.953 300.55 5.26
15.954-17.404 422.15 7.39
17.405-18.854 602.55 10.55
18.855-20.304 480.65 8.41
20.305-21.755 352.45 6.17
21.756-23.205 611.55 10.71
23.206-24.655 892.65 15.63
24.656-26.106 957.40 16.76
26.107-27.556 503.35 8.81
27.557-29.007 1.00 0.02
29.008-30.457 0.00 0.00
30.458-31.907 0.00 0.00
31.908-33.358 0.00 0.00
33.359-34.808 0.00 0.00
34.809-36.258 0.00 0.00
36.259-37.709 0.00 0.00
37.710-39.159 0.00 0.00
39.160-40.610 0.00 0.00
40.611-42.060 0.00 0.00
42.061-43.510 0.00 0.00
43.511-44.961 0.00 0.00
44.962-46.411 0.00 0.00
46.412-47.861 0.00 0.00
47.862-49.312 0.00 0.00
49.313-50.762 0.00 0.00
50.763-52.213 0.00 0.00
52.214-53.663 0.00 0.00
53.664-55.113 0.00 0.00
55.114-56.564 0.00 0.00
56.565-58.014 0.00 0.00
58.015-59.464 0.00 0.00
59.465-60.915 0.00 0.00
60.916-62.365 0.00 0.00
62.366-63.816 0.00 0.00
63.817-65.266 0.00 0.00
65.267-66.716 0.00 0.00
66.717-68.167 0.00 0.00
68.168-69.617 0.00 0.00
69.618-71.067 0.00 0.00
71.068-72.518 0.00 0.00
72.519-73.968 0.00 0.00
73.969-75.419 0.00 0.00
75.420-76.869 0.00 0.00
76.870-78.319 0.00 0.00
78.320-79.770 0.00 0.00
79.771-81.220 0.00 0.00
81.221-82.670 0.00 0.00
82.671-84.121 0.00 0.00
84.122-85.571 0.00 0.00
85.572-87.023 0.00 0.00
>87.023 0.00 0.00

Lifetime:Accumulated Time vs Engine Coolant Temperature - C18 390F (TXW01233)

Engine Coolant Temperature( hours %
Deg F )
<32.00 0.00 0.00
32.00-40.99 0.00 0.00
41.00-49.99 0.05 0.00
50.00-58.99 0.35 0.00
59.00-67.99 1.00 0.00
68.00-76.99 2.15 0.01
77.00-85.99 3.50 0.01
86.00-94.99 5.15 0.02
95.00-103.99 6.55 0.03
104.00-112.99 9.10 0.04
113.00-121.99 13.50 0.06
122.00-130.99 19.05 0.08
131.00-139.99 32.75 0.14
140.00-148.99 61.95 0.26
149.00-157.99 104.10 0.43
158.00-166.99 179.45 0.74
167.00-175.99 1352.15 5.60
176.00-184.99 22052.90 91.27
185.00-193.99 293.15 1.21
194.00-202.99 20.35 0.08
203.00-211.99 3.25 0.01
212.00-220.99 0.75 0.00
221.00-229.99 0.25 0.00
230.00-238.99 0.00 0.00
239.00-247.99 0.00 0.00
248.00-256.99 0.00 0.00
257.00-265.99 0.00 0.00
266.00-274.99 0.00 0.00
275.00-283.99 0.00 0.00
284.00-292.99 0.00 0.00
293.00-302.00 0.00 0.00
>302.00 0.00 0.00

Engine Overspeed Histogram: Accumulated Time (sec) vs Engine Speed - C18 390F (TXW01233)
Engine Speed( rpm ) %
2500.0-2599.9 0.00 0.00
2600.0-2699.9 0.00 0.00
2700.0-2799.9 0.00 0.00
2800.0-2899.9 0.00 0.00
2900.0-2999.9 0.00 0.00
3000.0-3099.9 0.00 0.00
3100.0-3199.9 0.00 0.00
3200.0-3299.9 0.00 0.00
3300.0-3400.0 0.00 0.00
>3400.0 0.00 0.00

Lifetime:Accumulated Time vs Engine Speed And Percent Engine Load at Current Engine Speed -
C18 390F (TXW01233)
rpm <600.0 600.0- 650.0- 700.0- 750.0- 800.0- 850.0- 900.0- 950.0-
649.9 699.9 749.9 799.9 849.9 899.9 949.9 999.9
%
<0.0 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00
0.0-9.9 0.00 0.00 0.00 0.00 0.00 0.05 0.15 0.35 547.85
10.0- 0.00 0.00 0.00 0.00 0.00 0.00 0.05 0.10 0.95
19.9
20.0- 0.00 0.00 0.00 0.00 0.00 0.00 0.05 0.10 0.65
29.9
30.0- 0.00 0.00 0.00 0.00 0.00 0.00 0.05 0.05 0.35
39.9
40.0- 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.05 0.25
49.9
50.0- 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.05 0.25
59.9
60.0- 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.05 0.25
69.9
70.0- 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.05 0.15
79.9
80.0- 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.05 0.10
89.9
90.0- 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.05 0.10
100.0
>100.0 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00
Total 0.00 0.00 0.00 0.00 0.00 0.05 0.30 0.90 550.90
Lifetime:Accumulated Time vs Engine Speed And Percent Engine Load at Current Engine Speed -
C18 390F (TXW01233)
rpm 1000.0- 1050.0- 1100.0- 1150.0- 1200.0- 1250.0- 1300.0- 1350.0- 1400.0-
1049.9 1099.9 1149.9 1199.9 1249.9 1299.9 1349.9 1399.9 1449.9
%
<0.0 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00
0.0-9.9 640.85 4407.95 32.75 15.35 12.05 12.95 10.70 15.45 14.45
10.0- 1.05 0.25 0.15 0.20 0.10 0.30 0.10 0.25 0.30
19.9
20.0- 0.75 0.20 0.15 0.40 0.15 0.40 0.10 0.20 0.35
29.9
30.0- 0.40 0.15 0.15 0.20 0.10 0.20 0.10 0.15 0.25
39.9
40.0- 0.40 0.15 0.10 0.15 0.10 0.15 0.10 0.10 0.20
49.9
50.0- 0.40 0.15 0.05 0.10 0.15 0.20 0.20 0.20 0.30
59.9
60.0- 0.40 0.20 0.15 0.40 0.80 1.10 1.40 1.65 1.85
69.9
70.0- 0.20 0.55 0.75 1.35 1.85 2.35 2.95 3.05 2.85
79.9
80.0- 0.15 0.45 1.05 1.90 2.10 2.40 2.70 2.50 2.45
89.9
90.0- 0.15 0.35 0.65 1.30 1.55 1.75 2.05 2.60 4.70
100.0
>100.0 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00
Total 644.75 4410.40 35.95 21.35 18.95 21.80 20.40 26.15 27.70

Lifetime:Accumulated Time vs Engine Speed And Percent Engine Load at Current Engine Speed -
C18 390F (TXW01233)
rpm 1450.0- 1500.0- 1550.0- 1600.0- 1650.0- 1700.0- 1750.0- 1800.0- 1850.0-
1499.9 1549.9 1599.9 1649.9 1699.9 1749.9 1799.9 1849.9 1899.9
%
<0.0 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00
0.0-9.9 11.55 14.25 48.05 168.10 1234.55 492.95 36.35 19.70 12.45
10.0- 0.90 3.70 22.00 115.05 457.70 163.10 22.25 8.40 11.00
19.9
20.0- 1.15 3.60 21.00 106.25 308.95 196.55 25.40 8.10 10.85
29.9
30.0- 0.90 3.25 17.95 103.65 371.90 270.00 34.65 11.30 27.40
39.9
40.0- 0.80 2.90 17.05 105.00 440.75 338.80 46.80 15.85 45.10
49.9
50.0- 0.80 2.75 16.45 104.40 606.35 492.20 61.45 22.20 53.95
59.9
60.0- 2.40 4.20 17.40 102.75 713.00 721.90 73.65 27.30 60.45
69.9
70.0- 3.15 4.75 19.50 100.80 695.65 791.50 80.25 28.85 63.50
79.9
80.0- 2.95 5.90 32.80 123.05 790.95 952.75 89.25 31.65 61.15
89.9
90.0- 8.15 32.60 204.45 833.55 2338.25 1795.15 172.25 99.35 145.50
100.0
>100.0 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00
Total 32.75 77.90 416.65 1862.60 7958.05 6214.90 642.30 272.70 491.35

Lifetime:Accumulated Time vs Engine Speed And Percent Engine Load at Current Engine Speed -
C18 390F (TXW01233)
rpm 1900.0- 1950.0- 2000.0- 2050.0- 2100.0- 2150.0- 2200.0- 2250.0- 2300.0-
1949.9 1999.9 2049.9 2099.9 2149.9 2199.9 2249.9 2299.9 2349.9
%
<0.0 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00
0.0-9.9 2.90 0.40 0.00 0.00 0.00 0.00 0.00 0.00 0.00
10.0- 3.60 0.05 0.00 0.00 0.00 0.00 0.00 0.00 0.00
19.9
20.0- 5.05 0.10 0.00 0.00 0.00 0.00 0.00 0.00 0.00
29.9
30.0- 14.45 0.15 0.00 0.00 0.00 0.00 0.00 0.00 0.00
39.9
40.0- 32.30 0.25 0.00 0.00 0.00 0.00 0.00 0.00 0.00
49.9
50.0- 38.90 0.40 0.00 0.00 0.00 0.00 0.00 0.00 0.00
59.9
60.0- 48.50 0.60 0.00 0.00 0.00 0.00 0.00 0.00 0.00
69.9
70.0- 55.60 0.80 0.00 0.00 0.00 0.00 0.00 0.00 0.00
79.9
80.0- 54.85 0.85 0.00 0.00 0.00 0.00 0.00 0.00 0.00
89.9
90.0- 77.70 1.20 0.00 0.00 0.00 0.00 0.00 0.00 0.00
100.0
>100.0 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00
Total 333.85 4.80 0.00 0.00 0.00 0.00 0.00 0.00 0.00

Lifetime:Accumulated Time vs Engine Speed And Percent Engine Load at Current Engine Speed -
C18 390F (TXW01233)
rpm 2350.0-2400.0 >2400.0 Total
%
<0.0 0.00 0.00 0.00
0.0-9.9 0.00 0.00 7752.15
10.0-19.9 0.00 0.00 811.55
20.0-29.9 0.00 0.00 690.50
30.0-39.9 0.00 0.00 857.75
40.0-49.9 0.00 0.00 1047.35
50.0-59.9 0.00 0.00 1401.90
60.0-69.9 0.00 0.00 1780.40
70.0-79.9 0.00 0.00 1860.45
80.0-89.9 0.00 0.00 2162.00
90.0-100.0 0.00 0.00 5723.40
>100.0 0.00 0.00 0.00
Total 0.00 0.00 24087.45
Lifetime:Accumulated Time vs Intake Manifold Air Temperature - C18 390F (TXW01233)
Intake Manifold Air hours %
Temperature( Deg F )
<32.00 0.00 0.00
32.00-40.99 0.75 0.00
41.00-49.99 5.85 0.02
50.00-58.99 70.40 0.29
59.00-67.99 358.70 1.48
68.00-76.99 869.35 3.60
77.00-85.99 1149.70 4.76
86.00-94.99 2152.45 8.91
95.00-103.99 4891.95 20.25
104.00-112.99 5625.05 23.28
113.00-121.99 4474.15 18.52
122.00-130.99 2905.15 12.02
131.00-139.99 1230.70 5.09
140.00-148.99 362.10 1.50
149.00-157.99 57.35 0.24
158.00-166.99 8.00 0.03
167.00-175.99 0.20 0.00
176.00-184.99 0.05 0.00
185.00-193.99 0.05 0.00
194.00-202.99 0.05 0.00
203.00-211.99 0.00 0.00
212.00-220.99 0.00 0.00
221.00-229.99 0.00 0.00
230.00-238.99 0.00 0.00
239.00-248.00 0.00 0.00
>248.00 0.00 0.00

High Exhaust Temperature Prevention Derate Time - C18 390F (TXW01233)

Deg F <104.00 104.00- 113.00- 122.00- 131.00- 140.00- 149.00- 158.00- 167.00-
112.99 121.99 130.99 139.99 148.99 157.99 166.99 175.99
psi
<8.702 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00
8.702- 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00
9.862
9.863- 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00
11.022
11.023- 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00
12.182
12.183- 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00
13.342
13.343- 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00
14.504
>14.504 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00
Total 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00
High Exhaust Temperature Prevention Derate Time - C18 390F (TXW01233)
Deg F 176.00- 185.00- 194.00- 203.00- >212.00 Total
184.99 193.99 202.99 212.00
psi
<8.702 0.00 0.00 0.00 0.00 0.00 0.00
8.702-9.862 0.00 0.00 0.00 0.00 0.00 0.00
9.863-11.022 0.00 0.00 0.00 0.00 0.00 0.00
11.023- 0.00 0.00 0.00 0.00 0.00 0.00
12.182
12.183- 0.00 0.00 0.00 0.00 0.00 0.00
13.342
13.343- 0.00 0.00 0.00 0.00 0.00 0.00
14.504
>14.504 0.00 0.00 0.00 0.00 0.00 0.00
Total 0.00 0.00 0.00 0.00 0.00 0.00

Lifetime:Accumulated Time vs Engine Speed - C18 390F (TXW01233)

Engine Speed( rpm ) hours %
<550.0 0.00 0.00
550.0-599.9 0.00 0.00
600.0-649.9 0.00 0.00
650.0-699.9 0.00 0.00
700.0-749.9 0.00 0.00
750.0-799.9 0.00 0.00
800.0-849.9 0.10 0.00
850.0-899.9 0.40 0.00
900.0-949.9 0.95 0.00
950.0-999.9 609.15 2.51
1000.0-1049.9 717.15 2.95
1050.0-1099.9 4480.65 18.46
1100.0-1149.9 37.30 0.15
1150.0-1199.9 22.45 0.09
1200.0-1249.9 19.40 0.08
1250.0-1299.9 23.15 0.10
1300.0-1349.9 20.75 0.09
1350.0-1399.9 27.10 0.11
1400.0-1449.9 28.60 0.12
1450.0-1499.9 33.50 0.14
1500.0-1549.9 78.70 0.32
1550.0-1599.9 420.30 1.73
1600.0-1649.9 1865.30 7.69
1650.0-1699.9 7930.75 32.68
1700.0-1749.9 6194.00 25.52
1750.0-1799.9 642.95 2.65
1800.0-1849.9 274.00 1.13
1850.0-1899.9 498.00 2.05
1900.0-1949.9 339.85 1.40
1950.0-1999.9 4.85 0.02
2000.0-2049.9 0.00 0.00
2050.0-2099.9 0.00 0.00
2100.0-2149.9 0.00 0.00
2150.0-2199.9 0.00 0.00
2200.0-2249.9 0.00 0.00
2250.0-2299.9 0.00 0.00
2300.0-2349.9 0.00 0.00
2350.0-2399.9 0.00 0.00
2400.0-2449.9 0.00 0.00
2450.0-2499.9 0.00 0.00
2500.0-2549.9 0.00 0.00
2550.0-2599.9 0.00 0.00
2600.0-2649.9 0.00 0.00
2650.0-2699.9 0.00 0.00
2700.0-2749.9 0.00 0.00
2750.0-2799.9 0.00 0.00
2800.0-2849.9 0.00 0.00
2850.0-2899.9 0.00 0.00
2900.0-2949.9 0.00 0.00
2950.0-2999.9 0.00 0.00
3000.0-3049.9 0.00 0.00
3050.0-3099.9 0.00 0.00
3100.0-3149.9 0.00 0.00
3150.0-3199.9 0.00 0.00
3200.0-3249.9 0.00 0.00
3250.0-3299.9 0.00 0.00
3300.0-3349.9 0.00 0.00
3350.0-3400.0 0.00 0.00
>3400.0 0.00 0.00

Lifetime:Accumulated Time vs Air Inlet Temperature - C18 390F (TXW01233)

Air Inlet Temperature( Deg F ) hours %
<(-4.00) 0.00 0.00
(-4.00)-4.99 0.00 0.00
5.00-13.99 0.00 0.00
14.00-22.99 0.00 0.00
23.00-31.99 0.30 0.00
32.00-40.99 24.80 0.10
41.00-49.99 203.75 0.84
50.00-58.99 658.45 2.73
59.00-67.99 1377.45 5.70
68.00-76.99 2627.85 10.88
77.00-85.99 3922.60 16.24
86.00-94.99 4271.75 17.68
95.00-103.99 4719.70 19.53
104.00-112.99 3304.30 13.68
113.00-121.99 1751.80 7.25
122.00-130.99 857.00 3.55
131.00-139.99 339.05 1.40
140.00-148.99 89.75 0.37
149.00-157.99 12.60 0.05
158.00-166.99 0.15 0.00
167.00-176.00 0.00 0.00
>176.00 0.00 0.00

High Turbo Speed Prevention Derate Time - C18 390F (TXW01233)

Deg F <41.00 41.00- 59.00- 77.00- 95.00- 113.00- 131.00- >149.00 Total
58.99 76.99 94.99 112.99 130.99 149.00
psi
<8.702 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00
8.702- 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00
9.862
9.863- 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00
11.022
11.023- 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00
12.182
12.183- 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00
13.342
13.343- 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00
14.504
>14.504 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00
Total 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00

Injector Trim Calibration - C18 390F (TXW01233)

Injector Serial Number File Version
Injector1 000000005A530268013B 0
Injector2 000000005A53028070C2 0
Injector3 000000005A53028017A9 0
Injector4 000000005A53028076D0 0
Injector5 000000005A53028064CB 0
Injector6 000000005A5302800891 0

Monitoring System - C18 390F (TXW01233)

Description State Trip Point Delay Time
Engine Overspeed
Least Severe (1) Always On 2500 rpm 0 sec
Most Severe (3) Always On 2700 rpm 0 sec
Fuel Filter (Suction
Side) Restriction
Least Severe (1) Always On 70.0 % 1 sec
Moderate Severity (2) Always On 100.0 % 1 sec
Fuel Filter Restriction
Least Severe (1) Always On 70 % 1 sec
Moderate Severity (2) Always On 100 % 1 sec
High Air Inlet #1
Differential Pressure
Least Severe (1) Always On 0.9 psi 0 sec
Moderate Severity (2) Always On 0.9 psi 0 sec
High Engine Coolant
Temperature
Least Severe (1) Always On 228 Deg F 10 sec
Moderate Severity (2) Always On 232 Deg F 20 sec
High Fuel Temperature
Moderate Severity (2) Always On 203.0 Deg F 30 sec
High Fuel/Water
Separator Water Level
Least Severe (1) Always On None 40 sec
Moderate Severity (2) Always On None 3600 sec
High Intake Manifold
Air Temperature
Least Severe (1) Always On 179.6 Deg F 8 sec
Moderate Severity (2) Always On 186.8 Deg F 8 sec
Low Engine Oil
Pressure
Least Severe (1) Always On None 8 sec
Most Severe (3) Always On None 4 sec

Machine Control 390F

Parameter Value
Product ID
Application Number Unavailable
ECM Part Number 3095710-04
ECM Serial Number 1844F067EV
Software Group Part Number 4658557-00
Software Group Release Date NOV2014
Software Group Description 390F HEX CONTROL

Logged Diagnostic Codes [Diagnostic Clock = 8483 hours] - Machine Control 390F
Code Description Occ. First Last
438- 5 Hydraulic Control Valve Warm Up Solenoid #1 : 198 7582 8477
Current Below Normal
439- 5 Hydraulic Control Valve Warm Up Solenoid #2 : 210 7582 8477
Current Below Normal
2075- 9 Hydraulic System Valve ECM #1 CAN Data Link 2 7757 8115
#1 : Abnormal Update Rate
2076- 9 Hydraulic System Valve ECM #2 CAN Data Link 1 8115 8115
#1 : Abnormal Update Rate
2076-14 Hydraulic System Valve ECM #2 CAN Data Link 2 7757 8115
#1 : Special Instruction
41- 6 8 Volt DC Supply : Current Above Normal 9 7803 7901
2075-14 Hydraulic System Valve ECM #1 CAN Data Link 1 0 0
#1 : Special Instruction

Logged Event Codes [Diagnostic Clock = 8483 hours] - Machine Control 390F
Code Description Occ. First Last
E179 (2) Alternator Not Charging 3 8336 8336
E875 (2) Low System Voltage 7 8299 8336
Active Diagnostic Codes - Machine Control 390F
Code Description
No Active
Diagnostic
Codes

Active Event Codes - Machine Control 390F

Code Description
No Active
Event Codes

Current Totals - Machine Control 390F

Description Value Unit
Total Operating Hours 8483 hours
Engine Maintenance Hours 8481 hours
Engine Oil Hours 0 hours
Engine Oil Filter Hours 0 hours
Engine Coolant Hours 725 hours
Fuel/ Water Separator Hours 0 hours
Secondary Fuel Filter Hours 0 hours
Tertiary Fuel Filter Hours 0 hours
Fuel Tank Cap Hours 725 hours
Crankcase Ventilation Filter 8481 hours
Hours
Hydraulic Pump Hours 8481 hours
Hydraulic Pilot Oil Filter Hours 0 hours
Hydraulic Case Drain Oil Filter 0 hours
Hours
Return Hydraulic Oil Filter 725 hours
Hours
Hydraulic Oil Hours 725 hours
Final Drive Oil Hours 725 hours
Swing Motor Hours 4308 hours
Swing Drive Oil Hours 725 hours
Travel Motor Hours 630 hours
Fuel Priming Pump Hours 3479 hours
Tool #1 Hours 0 hours
Tool #2 Hours 0 hours
Tool #3 Hours 0 hours
Tool #4 Hours 0 hours
Tool #5 Hours 0 hours
Tool #6 Hours 0 hours
Tool #7 Hours 0 hours
Tool #8 Hours 0 hours
Tool #9 Hours 0 hours
Tool #10 Hours 0 hours
Refueling Pump Hours Unavailable hours
Refueling Pump Screen Hours Unavailable hours
Configuration - Machine Control 390F
Description Value Unit
Product ID
Application Number Unavailable
Hydraulic Power Mode High
Hydraulic Power High Mode Selection Enabled
Display Enable Status
Hydraulic Power Standard Mode Selection Disabled
Display Enable Status
Lighting Shutdown Timer Duration 1 min
Monitoring System Configuration Code Unavailable
Implement Pump Configuration Code Unavailable
DPF Installation Status Unavailable
Travel Alarm Installation Status Installed
Hydraulic Oil Automatic Warm Up Feature Disabled
Enable Status
Hydraulic Oil Automatic Warm Up 104 Deg F
Temperature Setpoint
Quick Coupler Installation Status Not Installed
Smart Boom Installation Status Not Installed
Water Separator Level Switch Not Installed
Configuration
Attachment Hydraulic Oil Filter Switch Not Installed
Configuration
Machine Overload Pressure Sensor Not Installed
Installation
Fuel Tank Maximum Volume 330 gal
Heavy Lift System Installation Status Not Installed
Machine Lockout System Installation Not Installed
Status
Boom Lower Check Valve Installation Not Installed
Status
Stick Lower Check Valve Installation Status Not Installed
Excavator Boom Configuration Reach
Combining Valve Gain 13.369 mm/Amp
Straight Travel Valve Gain 13.309 mm/Amp
Pump to Swing Motor Left Valve Gain 13.519 mm/Amp
Pump to Swing Motor Right Valve Gain 13.319 mm/Amp
Straight Travel Solenoid Minimum Current Unavailable Amps
Combining Solenoid Off Mode Current Unavailable Amps
Pump to Swing Motor Left Solenoid Unavailable Amps
Minimum Current
Pump to Swing Motor Right Solenoid Unavailable Amps
Minimum Current
Straight Travel Pedal Installation Status Not Installed
Machine Application Configuration Bucket
Joystick Mapping Group Selection Two Way
Joystick Mapping Configuration SAE Mapping
Travel Speed Shift Low Delay 0.4 sec
Travel Speed Shift High Delay 0.4 sec
Travel Speed Shift Low Pres 3481 psi
Travel Speed Shift High Pressure 4786 psi
One Touch Engine Speed Setting 1060 rpm
AESC Setting 1060 rpm
AESC Delay Time 5.0 sec
Throttle Dial Position 1 Engine Speed 1000 rpm
Throttle Dial Position 2 Engine Speed 1060 rpm
Throttle Dial Position 3 Engine Speed 1120 rpm
Throttle Dial Position 4 Engine Speed 1180 rpm
Throttle Dial Position 5 Engine Speed 1280 rpm
Throttle Dial Position 6 Engine Speed 1400 rpm
Throttle Dial Position 7 Engine Speed 1500 rpm
Throttle Dial Position 8 Engine Speed 1600 rpm
Throttle Dial Position 9 Engine Speed 1650 rpm
Throttle Dial Position 10 Engine Speed 1700 rpm
Throttle Dial Position 1 Hydraulic System 49.0 %
Torque Percentage
Throttle Dial Position 2 Hydraulic System 49.0 %
Torque Percentage
Throttle Dial Position 3 Hydraulic System 54.0 %
Torque Percentage
Throttle Dial Position 4 Hydraulic System 63.0 %
Torque Percentage
Throttle Dial Position 5 Hydraulic System 77.0 %
Torque Percentage
Throttle Dial Position 6 Hydraulic System 88.0 %
Torque Percentage
Throttle Dial Position 7 Hydraulic System 94.0 %
Torque Percentage
Throttle Dial Position 8 Hydraulic System 97.0 %
Torque Percentage
Throttle Dial Position 9 Hydraulic System 99.0 %
Torque Percentage
Throttle Dial Position 10 Hydraulic System 100.0 %
Torque Percentage
Swing Priority Over Boom Raise Setting Unavailable
Adjustment
Swing Priority Multi-Function Enable Status Unavailable
Swing Priority Over Boom Raise Setting Unavailable
Swing Priority Over Boom Lower Setting Unavailable
Swing Priority Over Stick Out Setting Unavailable
Swing Priority Over Stick In Setting Unavailable
Swing Priority Over Bucket Dump Setting Unavailable
Swing Priority Over Bucket Curl Setting Unavailable
Swing Priority Setting Unavailable
Boom Deceleration Setting Unavailable
Spool Gain Selection Unavailable
Engine Oil Recommended Maintenance 250 hours
Interval
Engine Oil Filter Recommended 250 hours
Maintenance Interval
Engine Coolant Recommended 3000 hours
Maintenance Interval
Fuel/ Water Separator Recommended 250 hours
Maint Interval
Secondary Fuel Filter Recommended 250 hours
Maintenance Interval
Tertiary Fuel Filter Recommended 250 hours
Maintenance Interval
Fuel Pump Screen Filter Recommended 0 hours
Maintenance Interval
Fuel Tank Cap Recommended 1000 hours
Maintenance Interval
Hydraulic Pilot Oil Filter Recommended 500 hours
Maintenance Interval
Hydraulic Case Drain Oil Filter 500 hours
Recommended MI
Return Hyd Oil Filter Recommended Maint 2000 hours
Interval
Attachment Hydraulic Oil Filter 0 hours
Recommended Maintenance Interval
Final Drive Oil Recommended 2000 hours
Maintenance Interval
Hydraulic Oil Recommended Maintenance 5000 hours
Interval
Swing Drive Oil Recommended 1000 hours
Maintenance Interval
Aftertreatment DEF Injector Recommended 0 hours
Maintenance Interval
Soft Mode Response Selection Slow
Quick Mode Response Selection Fast
Grade Control System Installation Status Not Installed
Production Measurement Feature Unavailable
Installation Status
Production Measurement Feature Unavailable
Temporary Installation Status
Production Measurement Feature Unavailable min
Temporary Installation Time Remaining
Advanced Machine Security System Not Installed
Installation Status
Total Tattletale Unavailable

Calibration Status - Machine Control 390F

Calibration Status Last Successful Completion
PRV - Variable Relief Pressure Not Calibrated Never Successfully Calibrated
Calibration Solenoid 2
PRV - Variable Relief Pressure Not Calibrated Never Successfully Calibrated
Calibration Solenoid 1
Swing Valve Calibration Success 6014.0 hours
Hydraulic Pumps Swash Plate Success 6314.2 hours
Angle Calibration
Straight Travel Valve Success 6005.1 hours
Calibration
Stick Valve Calibration Not Calibrated Never Successfully Calibrated
PRV - Power Shift Pressure Failed 7113.9 hours
Calibration
Error: 0006 Aborted by user
Error: 0009 Aborted by ECM
PRV - Flow Meter for Two Not Calibrated Never Successfully Calibrated
Pump Flow Combined
Right Attachment Pedal Failed 0.4 hours
Calibration
Error: 000B Calibration not
supported
Error: 0009 Aborted by ECM
Left Attachment Pedal Failed 0.4 hours
Calibration
Error: 000B Calibration not
supported
Error: 0009 Aborted by ECM
Right Joystick Thumbwheel Failed 0.3 hours
Calibration
Error: 000B Calibration not
supported
Error: 0009 Aborted by ECM
Left Joystick Thumbwheel Failed 0.3 hours
Calibration
Error: 000B Calibration not
supported
Error: 0009 Aborted by ECM
Left Joystick Left/Right Lever Success 7146.4 hours
Left Joystick Forward/ Success 7146.4 hours
Backward Lever
Right Joystick Left/Right Lever Success 0.4 hours
Right Joystick Success 0.4 hours
Forward/Backward Lever
Combiner Valve #1 Calibration Success 6014.1 hours
Stick Lowering Check Valve Not Calibrated Never Successfully Calibrated
Calibration
Boom Lowering Check Valve Failed 0.2 hours
Calibration
Error: 0006 Aborted by user
Error: 0009 Aborted by ECM
Bypass Valve #2 Calibration Success 6014.0 hours
Bypass Valve #1 Calibration Success 6014.0 hours
Bucket Valve Calibration Not Calibrated Never Successfully Calibrated
Boom Valve Calibration Not Calibrated Never Successfully Calibrated
Attachment Valve #2 Retract Not Calibrated Never Successfully Calibrated
Attachment Valve #2 Extend Not Calibrated Never Successfully Calibrated
Attachment Valve #1 Retract Not Calibrated Never Successfully Calibrated
Attachment Valve #1 Extend Not Calibrated Never Successfully Calibrated
Attachment #1 Valve Not Calibrated Never Successfully Calibrated
Calibration

Tool Configuration - Machine Control 390F

Description Value Unit
Tool Program Name 0
Tool Program Tool Type Bucket
Maximum Throttle Dial 10
Minimum Throttle Dial Position 1
Fuel Economy Mode Enable Enabled
Status
Hydraulic Temperature High 258.8 Deg F
Warning Event Threshold
Work Tool Weight Configuration Standard

Description Value Unit

Tool Program Name 0
Tool Program Tool Type Bucket
Maximum Throttle Dial 10
Minimum Throttle Dial Position 1
Fuel Economy Mode Enable Enabled
Status
Hydraulic Temperature High 258.8 Deg F
Warning Event Threshold
Work Tool Weight Configuration Standard

Description Value Unit

Tool Program Name 0
Tool Program Tool Type Bucket
Maximum Throttle Dial 10
Minimum Throttle Dial Position 1
Fuel Economy Mode Enable Enabled
Status
Hydraulic Temperature High 258.8 Deg F
Warning Event Threshold
Work Tool Weight Configuration Standard

Description Value Unit

Tool Program Name 0
Tool Program Tool Type Bucket
Maximum Throttle Dial 10
Minimum Throttle Dial Position 1
Fuel Economy Mode Enable Enabled
Status
Hydraulic Temperature High 258.8 Deg F
Warning Event Threshold
Work Tool Weight Configuration Standard

Description Value Unit

Tool Program Name 0
Tool Program Tool Type Bucket
Maximum Throttle Dial 10
Minimum Throttle Dial Position 1
Fuel Economy Mode Enable Enabled
Status
Hydraulic Temperature High 258.8 Deg F
Warning Event Threshold
Work Tool Weight Configuration Standard

Description Value Unit

Tool Program Name 0
Tool Program Tool Type Bucket
Maximum Throttle Dial 10
Minimum Throttle Dial Position 1
Fuel Economy Mode Enable Enabled
Status
Hydraulic Temperature High 258.8 Deg F
Warning Event Threshold
Work Tool Weight Configuration Standard

Description Value Unit

Tool Program Name 0
Tool Program Tool Type Bucket
Maximum Throttle Dial 10
Minimum Throttle Dial Position 1
Fuel Economy Mode Enable Enabled
Status
Hydraulic Temperature High 258.8 Deg F
Warning Event Threshold
Work Tool Weight Configuration Standard

Description Value Unit

Tool Program Name 0
Tool Program Tool Type Bucket
Maximum Throttle Dial 10
Minimum Throttle Dial Position 1
Fuel Economy Mode Enable Enabled
Status
Hydraulic Temperature High 258.8 Deg F
Warning Event Threshold
Work Tool Weight Configuration Standard

Description Value Unit

Tool Program Name 0
Tool Program Tool Type Bucket
Maximum Throttle Dial 10
Minimum Throttle Dial Position 1
Fuel Economy Mode Enable Enabled
Status
Hydraulic Temperature High 258.8 Deg F
Warning Event Threshold
Work Tool Weight Configuration Standard

Description Value Unit

Tool Program Name 0
Tool Program Tool Type Bucket
Maximum Throttle Dial 10
Minimum Throttle Dial Position 1
Fuel Economy Mode Enable Enabled
Status
Hydraulic Temperature High 258.8 Deg F
Warning Event Threshold
Work Tool Weight Configuration Standard

Monitor System
Parameter Value
ECM Part Number 3095711-07
Software Group Part Number 4562195-00
Software Group Release Date Jan2014
Software Group Description E HEX MONITOR Application

Implement Control #2
Parameter Value
Product ID
Equipment ID
ECM Part Number 3173869-04
ECM Serial Number 1274F020EX
Software Group Part Number 4594693-00
Software Group Release Date MAR2014
Software Group Description Impl Slave 2 ACSB(Gen 3)

Logged Diagnostic Codes - Implement Control #2

Code Description Occ. First Last
168- 4 Electrical System Voltage : Voltage Below Normal 1 31449 31449

Logged Event Codes - Implement Control #2

Code Description Occ. First Last
No Logged
Event Codes

Active Diagnostic Codes - Implement Control #2

Code Description
No Active
Diagnostic
Codes
Active Event Codes - Implement Control #2
Code Description
No Active
Event Codes

Configuration - Implement Control #2

Description Value Unit
Product ID
Equipment ID
Pump To Stick Head End Solenoid 0.625 Amps
Minimum Current
Stick Head End To Tank Solenoid 0.657 Amps
Minimum Current
Pump To Stick Rod End Solenoid Minimum 0.609 Amps
Current
Stick Rod End To Tank Solenoid Minimum 0.628 Amps
Current
Pump To Stick Head End Valve Gain 13.409 mm/Amp
Stick Head End To Tank Valve Gain 13.249 mm/Amp
Pump To Stick Rod End Valve Gain 13.149 mm/Amp
Stick Rod End To Tank Valve Gain 13.279 mm/Amp
Pump To Attachment #1 Head End 0.650 Amps
Solenoid Minimum Current
Attachment #1 Head End To Tank Solenoid 0.650 Amps
Minimum Current
Pump To Attachment #1 Rod End Solenoid 0.650 Amps
Minimum Current
Attachment #1 Rod End To Tank Solenoid 0.650 Amps
Minimum Current
Pump To Attachment #1 Head End Valve 13.290 mm/Amp
Gain
Attachment #1 Head End To Tank Valve 13.290 mm/Amp
Gain
Pump To Attachment #1 Rod End Valve 13.290 mm/Amp
Gain
Attachment #1 Rod End To Tank Valve 13.290 mm/Amp
Gain

Implement Control #1
Parameter Value
Product ID
Equipment ID
ECM Part Number 3173869-04
ECM Serial Number 1274F019EX
Software Group Part Number 4594693-00
Software Group Release Date MAR2014
Software Group Description Impl Slave 1 ACSB(Gen 2&3)

Logged Diagnostic Codes - Implement Control #1

Code Description Occ. First Last
168- 4 Electrical System Voltage : Voltage Below Normal 1 31449 31449
Logged Event Codes - Implement Control #1
Code Description Occ. First Last
No Logged
Event Codes

Active Diagnostic Codes - Implement Control #1

Code Description
No Active
Diagnostic
Codes

Active Event Codes - Implement Control #1

Code Description
No Active
Event Codes

Configuration - Implement Control #1

Description Value Unit
Product ID
Equipment ID
Pump to Boom Head End Solenoid 0.650 Amps
Minimum Current
Boom Head End To Tank Solenoid 0.672 Amps
Minimum Current
Pump To Boom Rod End Solenoid 0.641 Amps
Minimum Current
Boom Rod End To Tank Solenoid Minimum 0.646 Amps
Current
Pump to Boom Head End Valve Gain 12.670 mm/Amp
Boom Head End To Tank Valve Gain 12.800 mm/Amp
Pump To Boom Rod End Valve Gain 12.739 mm/Amp
Boom Rod End To Tank Valve Gain 12.509 mm/Amp
Pump To Bucket Head End Solenoid 0.638 Amps
Minimum Current
Bucket Head End To Tank Solenoid 0.649 Amps
Minimum Current
Pump To Bucket Rod End Solenoid 0.655 Amps
Minimum Current
Bucket Rod End To Tank Solenoid 0.645 Amps
Minimum Current
Pump To Bucket Head End Valve Gain 12.739 mm/Amp
Bucket Head End To Tank Valve Gain 12.779 mm/Amp
Pump To Bucket Rod End Valve Gain 12.499 mm/Amp
Bucket Rod End To Tank Valve Gain 12.599 mm/Amp